Hazard factor analysis in the production
1. Deterioration of the source water quality
2. Pre-treatment filter like activated carbon filter or precision filter treatment process time too long or flow too big will lead bacteria reproduce. Filtration, ion exchange or reverse osmosis quality too bad will caused the bacteria reproduce。
3. Sterilized only by a small UV sterilization or use small ozone generator is directly added to the small amount of ozone sterilization, sterilization limited capacity, can not completely kill the bacteria in the pure water, the water quality after sterilization passing rate was 52.5%.
4. Long pipeline transportation and storage pipeline and storage tank is too large, the storage tank anticorrosion, long storage time, the bacteria easily contaminated breeding. Containers, pipes (especially pipe joints) and the quality is too poor, and its contents easily precipitate cause pollution.
5. Filling and Capping workshop without air conditioning or air purification and bacteria easily air pollution pure water filling, the artificial filling pure water easily caused by man-made pollution. Water after filling a pass rate of 40.0% versus 52.5% after the sterilization decreased, as shown in Table 1, which may be related to the pipeline transportation, storage and filling the related pollution. The caps unsterilized placed directly gland or cap disinfection time when the gland too long cap pollution, another bottle cap low quality, sealing lax, is also susceptible to bacterial contamination of the air.
6. Improper operation of the packaging and transportation staff, so the cap loose, bacteria easily enter the air and cause pollution.

Critical Control Point
1. Selection the best underground source water , Protection of the environment around source water to prevent contamination from the ground.
2. Filtration, ion exchange, reverse osmosis process Regular cleaning, replace the filter, or switch to larger models and the quality of the filter; regular treatment, replacement of ion exchange resins, reverse osmosis materials, or to switch to larger models and the quality is excellent exchange resins, reverse osmosis materials.
3. Sterilization Ozone generator switch to larger models or additional ozone mixing tower, ozone and pure water mix well to ensure thorough sterilization of pure water.Shenzhen Angel Suggestion 3 gram ozone for every 1000 Liter water.
4. Shorten the Pipeline transportation and storage. To shorten the length of the pipeline, to reduce the finished pure water storage capacity and storage time, storage workshop storage tank should have air conditioning and air purification facilities. The pipeline transporting purified water should enter the storage tank at the bottom rather than from the top into the one hand, can prevent ozone loss, on the other hand to prevent the germs in the purified water and air pollution caused. Quality assurance should be used containers, pipes, pipe fittings (stainless steel materials, etc.) to avoid precipitation of its contents contamination pure water, pipelines, containers should be regularly cleaned and disinfected.
5. Filling and capping Disinfection recoil bottle filling should be automated production lines, eliminate man-made pollution, the workshop should be air-conditioning and air purification facilities, to reduce the contamination of air quality clearance products, disinfectant should be used, to avoid secondary pollution recoil water the finished pure water should be used. Cap after the finished pure water rinse, and then by ozone disinfection and preservation. Cap quality must be good to avoid the cap loose, to ensure the finished pure water does not contamination. Martin Eden according Yunxiang Wang, Bing Weng, Zili Wang(Guangdong Province Sanitary Supervision Institute) article and design this system for shenzhen angel bottled water machinery,Any other company copy us is illegal and invalid.
6. Inspection Establish a strict inspection system, sampling and testing to finished the entire production process, from the source water.
HACCP system
In response to these hazards analysis critical control point pure water production control the comparison of water samples after various production processes, sterilization. Before and after sterilization after filling with a pass rate of finished products increased by 90.0%, 81.0%, 131.3%, 108.8%.

Quit tap water
Beijing’s  mostly professional drink water family don’t drink tap water over two decades.
Husband is in the drinking water industry committee of the National Development and Reform Commission Public Nutrition and Development Center, the wife is in charge of the protection Health Association Professional Committee of healthy drinking water, so the combination of dealing with drinking water for more than twenty years, talking about drinking water do not have natural modesty, “We might be Beijing’s most know drink water family, no people like us so professional in drinking water.” said 58-year-old wife Zhaofei Hong.
Drink “Kunlun Mountains”(One China Natural Mineral Bottled Water Brand), ” After half an hour Need go toilet, fast metabolism”.
“Volcanics” tea with Hainan Island, the Changbai Mountain Quanyangquan “,” tea use metasilicate, soft water.
Cooking is use Beijing local mineral water, Because at the end of the water treatment process has equipment which themselves design, rest assured that many.
The general family can’t offer the cost , because more than twenty years steeped in the drinking water sector, they accumulated hatred resources.
In a population of 20 million, Beijing, Very few family like Zhao Feihong couple which so well versed in tap water, purified water, mineral water secret.
The Beijing Guang’anmen overpass south’s office, filled two walls with water-related books. The face of a the office placing of a wide variety of high-end water bottle – Evian, Fei spring, summer wood, and whatnot, the pros and cons of every kind of water, Zhao Feihong can come in handy.
Many years research of the water quality, let them develop the habit of never let the tap water touch the lips.
“Last week we just measured, indicators (nitrogen) per liter more than nine milligrams of nitrate in tap water.” 2012 Christmas day, Zhao Feihong Southern Weekend reporter said, although this indicator does not exceed national standards prescribed 10mg / L standard value, but it has been very close, “five or six years ago, this indicator also 1-2mg / L in 2011, only four points a few.”
Nitrates in the tap water mainly from the garbage, filtrate and feces, which is just one of many indicators. Over the years, Zhao Feihong detection found in the gradual deterioration of the quality of tap water in Beijing, “It is an indisputable fact.
Been influenced by this couple, a lot friends and family around them quit the habit of drinking tap water, and became a supermarket mineral water counters regulars.

Zhaofei Hong truly recognize Beijing water by chance.
In the late 1980s, the rise of China’s aquaculture industry, the livestock professional background Zhaofei Hong originally to study health care products such as fish oil, steering additives in aquatic breeding. The unanticipated, additives flooding caused eutrophication, looking for active water activity of the material, in 1991, she began to wonder water treatment.
Until 2000, Zhao Feihong the activated material only to find not a panacea – to activate active at the same time, activated pollutants. What is a good water quality water has been lingering in her mind.
“Can not stay in the light to do experiments in the laboratory.” Day in March 2007, Zhao Feihong participate in city water inspection activities initiated by the environmental community of the capital – “music city water line” (hereinafter referred to as “music water line”) decided to explore Beijing’s water with their feet why there are good and bad points.
Time in more than five years, as one of the tens of thousands of the music water line volunteers, Zhao Feihong traveled almost all the rivers and lakes in the Beijing area and suburbs farthest time her foot over thirty kilometers .
In her eyes, the scene is not optimistic picture of the Beijing water started slowly.
Let her lament is the Miyun Reservoir. This reservoir is located in the Yanshan peaks of more than one hundred kilometers northeast of capital known as Beijing’s “Water for Life”.
“Crystal clear, direct drink no problem.” Zhaofei Hong came here in the 1980s when the memory. At the GB, the Miyun Reservoir quality can meet the standards for a class, and the surface water standards called the world’s most stringent water standards in Germany.
Once again came in 2011, when Zhao Feihong and of music water line volunteers Miyun puddle of clear and still, but Zhao Feihong know who swim in the Miyun Reservoir, the change has already happened.
Surface water standards revised in 2002, a water standard is only three categories of the year, while in recent years, according to a new national standard, the water quality of the Miyun Reservoir II water, “which means that now Miyun Reservoir The water quality has even the three categories of the year is not as good as “.
In 2002, Zhao Feihong good water began to study. In the eyes of the “the music water line” volunteers weekly morning, after five years of field trips, “they turned out to be specifically looking for good water, and we find bad water.
Of Landmark, ba, Ma Tso River Tonghuihe, Liangshuihe, Empress Xiao River, Shahe Yongding River …… sallow sewage scenes such as copy and paste like many rivers in the capital. New China’s first large-scale reservoirs – Guanting Reservoir serious pollution is already no longer assume the function of the source of drinking water, now only four water quality as an alternate source of water in Beijing.
“Pai so blatant, is scheduled to be so right and proper, is scheduled to be then a clear conscience.” The music water line, one of the founders of the Beijing water experts, Wang Jian, always conceal his anger.
Awkward blending of tap water
The Miyun water indeed has become old Zhao Feihong the memory.
Miyun Reservoir water after coagulation, filtration, disinfection program will be assigned to the capital’s top ten water plant, each the waterworks has its own wells, into the homes of ordinary people to the extraction of groundwater, groundwater and Miyun water blending.
Zhao Feihong admit, relative to the surface water, groundwater, or clean, but the water quality is going downhill.
In the 1980s, Beijing groundwater water pollution mainly arsenic, lead, heavy metals, especially the the Shijingshan the Shougang location, heavy metals exceeded more serious. But now, with the Shougang and other sources of pollution have been evictions, pollution protagonist is giving way to organic pollution.
Organic pollutants even in evolution. The “macromolecular organic matter in the eighties of the last century, is easy interception with activated carbon, ultrafiltration film, but a lot of organic matter now is a small molecule, the removal rate is very low.” Zhaofei Hong said. Tap water need to use liquid chlorine disinfection, these small organic molecules with liquid chlorine combined with easy to form disinfection byproducts, “This is the most terrible.
Compared blending water quality degradation, but the test of Beijing is a decline in the groundwater level in Beijing.
Three years ago, Zhao Feihong once detected help the water company pumped groundwater, found that water quality is not as good as originally pumped from three hundred meters, who would search for qualified clean water, can only dig to greater depths.
Public data shows that, from 1999 to 2009, the the Beijing the Groundwater average depth of 12 meters down to 24 meters, the urban centers has dropped to 30 meters. Beijing groundwater reserves are decreasing at an average annual rate of 500 million cubic meters.
“Still water wells around Beijing in the 1980s almost all was destroyed.” Zhaofei Hong said. Mentougou dining hall, known since ancient times, water town Spirit Water Village, the original large and small, 72 wells, and now, only two wells a little water and spiritual water village already transfiguration the water shortage village.
Zhaofei Hong told the Southern Weekend reporter, in the 1930s, under the Beijing dug twelve meters will be able to see the water, but now extracted groundwater has dug hundreds of meters from the water’s hardness 230mg / L increased to 400mg / L.
The “groundwater now must go through blending, too hard.” Zhaofei Hong. The so-called “hard”, refers to the calcium carbonate content of the water. “The water is too hard, her hair is sticky, washing powder, soap becomes unsaponifiable matter, children easily get dermatitis, eczema.
Usual sun, the river has dried up
In fact, when Zhaofei Hong and other volunteers on along the river upstream of the capital, the situation seems to be more bad.
“The elderly, Sanggan Where are you?”
“Here is Sanggan.”
Then the water? “
Sanggan which there is water, not enough cattle to drink it! “
In the the music water line “, Wang Jian, often with Zhaofei Hong and other volunteers to share this time two years ago, the dialogue, this is his dialogue for the elderly and a grazing in Yongding River upstream the Sanggan the river. “This DING Ling Sanggan that the sun is shining?” Wang Jian was a tight.
Past and Present of the Beijing Water tangible doors Qing Wang Jian, Zhao Feihong always admire their knowledge of the vast, however, the more admiration, more sadly – the water Lingling Beijing has passed away.
In the Yongding River Daxing elm cutting segment perennial water river and even built a sand sculpture park. In fact, Bu Wei the Yongding river basin, “the music water line” went Chaohe, Shirakawa, Gui River, Ju River an article about Beijing blood the dry riverbed frequently broke into Wang Jian and Zhao Feihong horizons.
In 2002, the Summer Palace lake dried up, when up to seven months. In 2007, the Summer Palace, Kunming Lake in winter and spring dried up, the size of the cruise ship ran aground in the mud, floating dock this shore Qi, deep mud, 17 hole under the bridge in the early spring, the dry lakebed actually kite enthusiasts fly by.
Three wells, two wells, seven wells, Wangfujing, called light wells alley there are more than 80 Sanlihe in the ditch, where’s the water river, ditch? “Wang Jian said,” Whatever think about the name of a place, you will find the close relationship between Beijing with water. “
History is not always the case. Shang and Zhou dynasties, Beijing the plains lakes and rivers swamp clouds, our ancestors had to ancient ferry traffic along the Taihang Road East. Zhongguancun West danleng Street, the Yuan is still sitting on hundreds of hectares of water surface danleng Pan. Even the 1950s, the west side of the Summer Palace, Yuquan Hill also there are a large number of rice fields describing here bucolic poetry, light Qianlong emperor made a few hundred first.
Just more than half a century, official figures show that per capita water resources in Beijing has dropped to less than 100 cubic meters, which has been less than the world’s water resources per capita amount. In 2008, figures released by the Beijing Water Authority, or per capita is less than 300 cubic meters.
Looking for water for the thirsty city
And all volunteers participate in the music water line “, Zhao Feihong been wanted to find a solution for this thirst of Beijing, she even with Wang Jian, a Beijing Water Environment and Water Resources research.
2007, when Zhao Feihong With this in doubt ask the Chinese Academy of Sciences, hydrogeologists Meng-Bear, she got a good answer – Beijing should build five large underground reservoir, easy to drain rainwater, flood storage since that to regulate bad harvests.
She is happy that the proposal is being put on the agenda. In Beijing, a nationwide mobilization of water-saving war is unfolding.
“Neighborhood committees to each hair saving faucet to avoid leaking, if not water-saving toilets do not let you use the” Zhaofei Hong said.
The price of water has also sent a signal. Residential water price in Beijing is now more than $ 4 a cubic bath industry high water consumption industry, the price of water has reached 60 yuan a cubic, “This may be in the country are not”.
The original approval of the wells in the 1980s, “Beijing can seal closure, around 2000, will be allowed to drill wells. Basically no mineral water plant in Beijing. Zhaofei Hong said.
In this super city, throttle, open source or more important. At present, Beijing, as a giant octopus-like, it thirsty tentacles Hebei, Shanxi and even farther Danjiangkou, reclaimed water, karst water, desalination of water and even the Yellow River water is also included in the scope of the government’s consideration.
However, Zhao Feihong was very worried, “Why the decline in water quality in Beijing in the past few years? Because tap water is too complicated.”
In 2010, Beijing experienced 11 years of continuous drought, had emergency water diversion from the Shanxi Datong Cetian Reservoir, Hebei friendship Reservoir Pot flow River Reservoir, the Xiangshui Fort Reservoir, Yunzhou Reservoir. Wang Jian found that time line to Cetian Reservoir, the Reservoir water Cetian four underwater lot of dead fish floating on the water.
“Beijing has spent a lot of money transferred to the water is contaminated water,” Wang said. For the upcoming year after the Beijing South-to-North Water Diversion water, people do not doubt that the plight of the capital with water can make a big difference, but doubt they linger in the mind of the Zhaofei Hong et al, all the way to the water, will be raging to The crowd swallowed it?
“The Wanquan Shiliquan Shuiyun Township, blue busy seeking to take advantage of dawn cool. The two sides Luk Yeung cicada sparse sparse, fragrant rice Wind canoes full collar.”
- Qing Emperor Qianlong Tsan Haidian scenery
He Weifang (Professor):
Beijing’s tap water has been very problematic, Beijing tap water, can not be used to make tea, there are a lot of scale. However, the water quality of various places in Beijing is not the same, some places do not scale Beida near a lot of scale.
Shortage of good rivers, lakes, missing some lush Beijing suburb is desolate suburbs slightly better place is always crowded. (Source: Southern Weekly)

2. Find a water source-
1. If your source water is unable to drinking directly,you only can use RO water purification to producing the bottled pure water.(like city water,tap water,river water,underground water,borehole water,salt water,well water,even sea water)
2. If you have a good water source,like spring water,mineral spring which is very clear. Use the cheap UF treatment to produce natural spring bottle water or natural mineral bottle water.But the source is treasure and hard to find.
3. If you still want to producing the mineral bottled water,you can addition some mineral concentrate into the pure water through the dosing equipment.

3. Register your company and brand name -
1. You need register a company at some Administration for Industry and Commerce.
2. You need register a bottled water brand named if you want expend in future.The name your water products will be known for. Branding is very important in business, so in addition to your business name, design a very professional logo for your product because perception is the best sales man. Make your brand stands out among others!

4. Employ worker-Best have relevant industry experience worker,at first at least seven workers normal semiautomatic line or automatic line. Because they are learning from install engineers,And after factory normal running or expend to hire more worker. And the first seven worker to be the manager.

5. Buy and install water bottling plant -
Shenzhen Angel Drinking Water Equipment Co.,Ltd manufacturers of bottling machines for the pure/mineral/spring water, beverage in China. We are China Wal-Mart and Carrefour 10 years supplier and build over hundred of water purification system and bottling plant for Government organization,high school,university,Armed Police Force. We have a team of 52 experienced technicians for installation and maintenance, which helps ensure the high quality of our products and top-ranking service as well.Your can through the follow link to know more about water bottling plan you are interesting and contact us for the quote program.
1000-2000BPH Semiautomatic Water Filling Line Solution
1500-3000BPH Automatic Water Filling Line Solution
3000-5000BPH Automatic Water Filling Line Solution
5000-6000BPH Automatic Water Bottling Plant
10000BPH Automatic Water Filling Line Solution

6. Get Food Administration Approved

7. Sell bottled water

8. Advertising

Note: More detailed process please find local professionals or administration to know.

A smart investor knows that the best product to deal on is the product in high demand, that automatically placed pure water production business “Investors Choice” any time. The demand doesn’t seems to go down very soon as it has become the most credible alternative means of getting anything close to clean drinkable water for the average Nigerian. Therefore, how do you cash in on the demand of sachet water to make money for yourself?

The business of sachet pure water production is quite simple, and here is going to run down the step by step guide how anyone who is interested in this business can get started easily without much stress. In water business just like every other business, the number one priority should be service to humanity then, the money will come naturally. Like any other consumables, life is involved so try and put everything in place properly. Here are the things needed to get started:

1. Get a place of business – You need to acquire a property or rent a place, getting your own property and developing it is the most desirable option as that will save you cost in the long run.

2. Register your business name – The name your water products will be known for. Branding is very important in business, so in addition to your business name, design a very professional logo for your product because perception is the best sales man. Make your brand stands out among others!

3. Sink a Borehole – The most common source of water for commercial drinking water production like sachet water and bottled water is borehole, let there be borehole within your premises for constant water supply to your pure water production factory.

4. Install Overhead Tanks – This will serves as reservoir to supply water to the distillation system, it has to be overhead to ensure proper pressure to be able to pump down the distillation chamber.

RO Water Purification System

5. Install Water purification System – Only after RO system or more high level equipment treatment water can be called pure water,other is clean water or spring water,mineral water or addition mineral water,Borehole water must use Reverse Osmosis water purification system to get the final pure water. RO system included raw water pump,quartz sand filter,active carbon filter,Precision filter(Like someone said 5u PP),Reverse osmosis membrane(America army tech,most use in bottled pure water industry),Ultraviolet sterilization assembly,Ozone generator

6. Get NAFDAC Approved (http://www.nafdac.gov.ng/)- NAFDAC Is the agency that supervise foods and drugs in Nigeria, you need their approval to carry out business that involved consumable products of which water is one of them.

7. Acquire Automatic sachet filling and sealing Machine – Automatic sealing machine cost FOB China Price USD1500. Go for the ones that seals or produces about 2000 sachets per hour.

8. Employ Staffs – You will need minimum of five persons to work in your factory for a start then increase with time as the demand may be.

9. Distribution Mechanism – Buy truck for your distribution of rent but renting can be expensive and disappointing most of the times. My recommendation is that you buy your own truck if you can afford it at the beginning.

10. Get Power Generation – You know the situation of power supply in Nigeria, except if things changes tomorrow. If not, you will need a standby power generating set, and 25KVA will be just perfect for the job.

With all these in place, you are good to go! For a start up and depending on what you already have like land and other things, you may need some money for a start up in order to get the sealing machines(USD 1500,freight to nigerica USD200,Import custom and freight cost USD 200), PE film(China price is USD 3.1/kg , One kilogram can produce 280psc bag water) , and pay for labour for about some months before it begin to yield profits. Your cost could be higher if you are also paying for rent and hiring trucks.

AS1000 Sachet Filling Machine

Assuming you have only one Automatic sachet filling machinery or named pouch filling machines that produces your sachet water and you can afford to have only one delivery van that distribute your products.

one automatic pouch filling machine (at 100% utilization)
Capacity: 2,000 sachets in 1hour
Let’s conclude that; On the average, you produce 1000 bags in 1hour, and assuming you was able to work for 4hours in a day.
i.e. one machine producing 4000 bags of pure water in a day. (sincerely, an average sachet water factory in Nigeria today produces between 700 bags to 800 bags per machine in a day) so it all depends on you.

So let’s also assume N70 per bag;
4000 bags x N70 per bag = N280,000 per day.
N280, 000 x 28 working days in a month = N,7840, 000 per month.
Wait and see; N7,840, 000 x 12 months in a year,
= N90, 408,000

Here are some other reasons this business is a must to anyone one who can afford it:
* Government has failed to provide the basic drinking water need of every household in Nigeria. So, everyone make provision for themselves and buying pure sachet water is one of the most reasonable option.
* The more the population increases, the more the need for people to drink water, and the more the demand for the product of sachet water.
* There is not going to be a day, people will stop drinking water. In fact, it is one of the most essential consumable product and the most consumed natural resources on earth.
* Sachet water currently has no close or partially close substitute in Nigeria where the majorities are poor to depend on bottled water which is more expensive.
* One can never run out of customers to supply to. The more the producers, the more the consumers of sachet water.
* The popularity of sachet water is growing on alarming rates even in towns and villages across Nigeria.
* At five naira for a sachet, pure water is very cheap and affordable to buy even by the poorest man on earth.
* It is a major source of revenue for the government, so the government is even encouraging more producers.
* There is really no distinction between the consumers, it is widely acceptable to the rich and the poor, and is used for events and parties.
* Consumption of sachet water is not restricted by any law or religious belief unlike alcohol or some other drinking products and has no side effects.
* The set up requires little start-up capital compared to other factories. with five to 10 million naira, you are go to go and the return is guaranteed.
* There is ready made market for the product. All you need is just produce, it is one of the product out there that requires no much marketing to get the product accepted as it is already accepted by nature.
* The payback period for the investment into the business is less than six months. It’s one business you confidently get loan to do start with 100% assurance that the business would pay.
* The return on Investment (ROI) is more than 50% and it is subject to increase on expansion of the business.
* It requires little or no periodical acquisition of raw materials for production; water is a free gift of nature.
Visit our web other pages and post for more information about water packaging industry.

Original author: Darlinton Omeh
Modify by: Martin Eden(www.water-filling.com)

Note: If you want do business in pellet mill,you may interesting in Invest In Wood Pelletizing Business

Chinese ” drinking water health standards ” ( GB5749-85 ) regulations, iron content is less than 0.3 /L, manganese content ≤ 0.1 /L, exceeds the standard of water by iron and manganese removal treatment. Long time drinking containing iron and manganese content high water also seriously affect health, production equipment corrosion ability.

The contents of iron and manganese in high water are generally used in catalyst ( such as manganese sand ) under the effect of dissolved Fe two or two valence manganese were oxidized into insoluble ferric or tetravalent manganese compounds, using manganese sand filter to remove the purpose of purifying function.

4Fe2++O2+10H2O 4Fe ( OH ) 3+8H

2Mn2++O2+2H2O 2MnO2+4H+

Volume of product:0.1L-2L
Production capacity:3200-4000BPH.

Contact Martin:
Email:angelmartineden@gmail.com
Company Web:www.water-filling.com
Mob:0086-13632976311
More information about this machine please check:http://www.water-filling.com/blow-molding-machine

NO NAME MODEL QC UNIT ORIGIN
1 Leakage switch RKN32A 1 PSC Tianzheng
2 Circuit breaker 3VE1 2 PSC Beijing
3 Fuse RT18-32 3 PSC Tianzheng
4 Gear motor NMRV063-60-80B5/550W 1 SET Light transmission
5 Relay MY2NJ 2 SET OMRON
6 Programmable K7M-DR20UE/G7E-RY08A 1 SET LG
7 Air pressure switch P6A 1 PSC Korea
8 Push button switch ZB2-BE102C 3 PSC Shanghai.
9 Indicator lamp AD16-22D/S 3 PSC Shanghai.
10 Proximity switch E3F3-D12 4 PSC OMRON
11 Air pressure electromagnetic valve 4V210-08 13 SET Taiwan Ya Deke
12 Oily water separator AFR-2000 1 SET Taiwan Ya Deke
13 Wash bottle bottle cylinder SC50*125 1 SET Taiwan Ya Deke
14 Filling the cylinder MAL40*100-CA 1 SET Taiwan Ya Deke
15 Capping cylinder SC50*50 1 SET Taiwan Ya Deke
16 Bottle top cylinder 40*25-CA 2 SET Taiwan Ya Deke
17 Bottle clamping cylinder 400*50-B 5 SET Taiwan Ya Deke
18 A bottle of cylinder MAL40*100-CA 4 SET Taiwan Ya Deke
19 Capping machine YCJZ40/4 1 SET Shandong golden saint
20 AC contactor GMC-22 2 PSC LG
21 Medicine washing pump BJZ037 1 SET Guangdong peak
22 Cleaning / filling pump BJZ037 1 SET Guangdong peak
23 Sorting machine YCJZ40/4 1 SET Shandong golden saint
24 Net washing electromagnetic valve Washing machine electromagnetic valve 1 SET Zhongshan
25 Filling valve YCD21-15S ( stainless steel ) 1 SET Guangdong Wing Chong
26 Switching power supply S-120-24 1 SET Taiwan
27 Touch screen MT6056i 1 SET Taiwan
28 The filling head Stainless steel 1 SET Guangdong
29 Screw head Stainless steel 1 SET Taiwan
30 Actual size 4000*950*1970 1 SET
31 Packing size 2000*950*1970 1 SET
32 Net weight
33 Gross weight
TOTAL FOB SHENZHEN PRICE USD 3,880.00
Video Address: http://www.youtube.com/watch?v=GS4Osd9NJZM
Remarks:
1. The above quotation is based on FOB SHENZHEN trade terms.
2. Payment Terms: 30% deposit TT before production and the rest before shipment TT or irrevocable L/C at sight.
3. The above quotation is valid for one month from the date issued.
4. Production Lead Time: 35 DAYS for equipments.
5. After-sales Service Terms: we provide one year limited warranty*1 and life-long support service for all of our products(except filters and filtering spares).
We offer a minimum of 0.5% spare parts or enough for one year supply each order. During the warranty period, if any product purchased from our company malfunctions, we will provide necessary technical support, or even send engineers to solve the problem with the buyer providing proper accommodation, all the fees for transportation,insurance and medicines, and salary for our engineers*1.
6. All the equipments or machines are highly accurate and must be safely grounded. We are not liable if the equipments or machines break down because of no grounding or bad grounding.

The engine and alternator as well as cooling system are mounted on the base frame, with anti-vibrating and shock resistant function. It is convenient for lifting the complete gen-sets. The generating set is designed and constructed for installation in a weather protected and sound-proof canopy. For durability and corrosion resistance, all iron and steel surfaces of fabrications have been treated for coating by grit blast cleaning. Then covered by a polyester powder paint which provides an excellent corrosion resistant surface.

Gen-sets have one year or 1000hr warranty time from the date of installation (according to the warranty term of manufacturer, whichever comes first). However due to the wrong operation by the operator or ignorance of maintenance, fragile parts and daily used accessory is beyond the warranty.